登車橋除銹噴漆如何做好？

登車橋http://m.8kvv.com/是使用各種鋼材經過加工而成的，同樣需要各種防護劑以及外表來防止登車橋鋼材主體直接接觸到空氣，或者水等容易造成鋼材生銹或者發生化學反應的物質。因長時間暴露在室外，可謂飽受風吹日曬，對于登車橋表面具有保護作用的油漆來說是很大的考驗。
Ramps are using a variety of steel products after processing, the same needs as well as the appearance of a variety of protectant to prevent direct contact Ramps steel body into the air, or water, is likely to cause the steel to rust or chemical reactions occur. Due to prolonged exposure to the outdoors, can be described as suffering from wind and sun, Ramps for a protective effect of the paint surface is a great test.

對于生產廠家噴漆前要注意的就是對支桿、上架、底架等進行完整的除銹，在這方面，除銹方法為機械除銹和利用除銹劑。除銹劑的使用即利用化學原理，該方法速度很快，除銹效率高。但相對來講，利用除銹劑對鐵板支架除銹，費用要高。機械除銹是對于鋼板，鋼材等大型鋼結構十分常用的方法。最大特點是：除銹速度較快快，效果好，相對來說除銹成本低，在除銹的同時，還能消除表面的毛刺，雜物，對表面有一定的美化作用?？煽刂菩愿?。需要相關工作人員細心耐心做好這項工作才能保證下一項的除銹工作能完成的更好。
For the first paint manufacturer to pay attention is to strut, shelves full of rust chassis, etc., in this regard, descaling method for mechanical descaling and use herbicides. The use of herbicides, that the use of chemical theory,this method is very fast, high efficiency rust. But relatively speaking, the use of herbicides on the iron bracket rust, the cost is higher. Mechanical descaling for steel, steel and other large steel structure is very commonly used method. Most important feature: rust faster fast, effective and relatively low cost rust in rust, while also eliminating the surface burr, debris on the surface has some landscaping. To high controllability. Related to patient care staff need to do a better job under the blasting work to ensure that one can be completed.

一般登車橋都需要噴上厚厚的油漆外層，用來保護內部的鋼材，邊緣部分用封膠封住與空氣接觸的部位。油漆的作用用來阻斷與空氣直接直接接觸，封膠也有類似的作用，而且封膠固化后可以減小邊緣的鋼材鋒利性，較少對外部物體的傷害。
Ramps are generally need to spray paint on thick outer layer to protect the interior of steel, with a sealant to seal the edge portion in contact with the air site. For blocking direct effect paint in direct contact with the air, the sealant has a similar effect, and can reduce post-cured sealant steel edge sharpness, and less damage to the external object.

登車橋http://m.8kvv.com/油漆的好壞，也是決定登車橋能否上就使用的一個因素，質量不好的油漆使用一段時間后容易脫落，進而造成鋼材繡花或者被侵蝕，造成鋼材硬質與韌度的不穩定性導致設備的不能正常使用，或者大大縮短設備壽命。
Ramps bad paint, Ramps also decide whether to use a factor, easy to fall off after the poor quality of the paint used for some time, and cause erosion or embroidered steel, causing the steel hard and Toughness can lead to instability of the normal use of the device, or shorten equipment life.